National Airlines Flight 102

National Airlines Flight 102
N949CA, the aircraft involved in the accident
Accident
DateApril 29, 2013 (2013-04-29)
SummaryCrashed after take-off due to load shift resulting in loss of control/overload of cargo
SiteBagram Airfield, Parwan Province, Afghanistan
34°54′59″N 069°14′24″E / 34.91639°N 69.24000°E / 34.91639; 69.24000
Aircraft
Aircraft typeBoeing 747-428BCF
Aircraft nameLori
OperatorNational Airlines
IATA flight No.N8102
ICAO flight No.NCR102
Call signNATIONAL CARGO 102
RegistrationN949CA
Flight originChâteauroux-Centre "Marcel Dassault" Airport, Châteauroux, France
StopoverCamp Bastion, Helmand Province, Afghanistan
Last stopoverBagram Airfield, Parwan Province, Afghanistan
DestinationAl Maktoum International Airport, Dubai, United Arab Emirates
Occupants7
Passengers0
Crew7
Fatalities7
Survivors0

National Airlines Flight 102 (N8102/NCR102) was a cargo flight operated by National Airlines between Camp Shorabak (formerly Camp Bastion) in Afghanistan and Al Maktoum Airport in Dubai, with a refueling stop at Bagram Airfield, Afghanistan. On 29 April 2013, the Boeing 747-400 operating the flight crashed moments after taking off from Bagram, killing all seven people on board.[1][2]

The subsequent investigation concluded that improperly secured cargo broke free during the take-off and rolled to the back of the cargo hold, crashing through the rear pressure bulkhead and disabling the rear flight control systems. This rendered the aircraft stuck in an uncontrollable pitch-up attitude and induced a stall, and made recovery by the pilots impossible.[3]

Accident

At the time of the crash, the airline had been operating between Camp Bastion and Dubai for a month.[1] The accident flight had originated in Camp Bastion, where it had been loaded with five heavy armoured vehicles, and had stopped at Bagram Airfield to refuel.[4][5] The aircraft then took off from Bagram's runway 03 at 15:30 local time and was climbing through 1,200 feet (370 m) when its nose rose sharply. The aircraft then stalled, banked right, and leveled off just before impact with the ground; the whole aircraft exploded into a large fireball, almost damaging the vehicles nearby.[1] The crash site was off the end of runway 03, within the perimeter of the airfield. All seven crew, all of whom were U.S. citizens,[6] (four pilots, two mechanics, and a loadmaster.[1]) died. No one on the ground was injured.

A thunderstorm was also in the vicinity of Bagram at the time of the crash and the wind changed direction by 120° during one hour commencing approximately 35 minutes before the crash.[7] A dashboard camera on a car in the vicinity of the runway end recorded the crash, which shows the aircraft pitching up, falling into a stall, and then sharply banking right after a slight bank to the left, indicating asymmetrical lift. The plane soon righted itself and then crashed at a shallow angle on the ground.[1] CNN stated that a government official speaking on the condition of anonymity confirmed the video's authenticity.[5]

Aircraft

The tail of Flight 102

The aircraft involved was a 20-year-old Boeing 747-428BCF,[note 1] registration N949CA,[8] S/N 25630, and named Lori.[7] It was manufactured in 1993 as a combi aircraft, and delivered to Air France and operate as passenger aircraft until 2007 before it was modified for service as a freighter with Air France Cargo, and was sold to National Airlines in 2010.[7] At the time of the crash, the aircraft was flying on behalf of the United States Air Force's Air Mobility Command.[1][6]

Crew

The captain was 34-year-old Brad Hasler, who had worked for the airline since 2004. He had 6,000 flight hours, including 440 hours on the Boeing 747.[9]: 6 [10][11][12] The first officer was 33-year-old Jamie Lee Brokaw, who had worked for the airline since 2009 and had 1,100 flight hours, with 209 of them on the Boeing 747.[9]: 10 The relief crew consisted of captain Jeremy Lipka, 37, and first officer Rinku Shumman, 32.[13][14] The loadmaster was 36-year-old Michael Sheets, who had worked for the airline since 2010.[9]: 7  The two mechanics were Gary Stockdale and Timothy "Tim" Garrett, both 51 years old.[14]

Aftermath

The crash interrupted the New Zealand Defence Force's (NZDF) withdrawal from Afghanistan, as it was only hours away from using another National Airlines aircraft to fly equipment out of the country; after the crash, the NZDF indefinitely postponed using National Airlines for its airlift requirements.[15]

The aircraft name Lori was transferred to another National Airlines 747 eight years later, which registered as N936CA and former Global SuperTanker Services aircraft.[16]

"Lori" was named after Lori Alf, the wife of company owner Chris Alf.[citation needed]

Investigation

An MRAP being loaded onto the aircraft at Camp Bastion on the day of the accident

The United States National Transportation Safety Board (NTSB) and the Afghanistan Civil Aviation Authority investigated the crash.[6] The NTSB reported in a 30 April 2013 press release that representatives of the Federal Aviation Administration and the Boeing Company would also provide technical expertise and aid in the investigation.[17]

On 2 June 2013, investigators from the Ministry of Transport and Civil Aviation of Afghanistan confirmed the load shift hypothesis as the starting point: the cargo of five mine resistant ambush protected vehicles (three Cougars and two Oshkosh M-ATV's), totaling 80 tons of weight, had not been properly secured. At least one armored vehicle had come loose and rolled backward, struck the E8 rack which housed both the cockpit voice recorder (CVR) and the flight data recorder (FDR), causing them to cease recording, and then crashed through the airplane's rear bulkhead, damaging it.[9]: 51–52  In the process it crippled key hydraulic systems and severely damaged the horizontal stabilizer mechanism, including breaking its jackscrew, rendering the airplane uncontrollable[3][9] and resulting in the abnormal pitch-up rotation, stall, and eventual crash.[1]

The NTSB determined that the probable cause of this accident was "National Airlines' inadequate procedures for restraining special cargo loads, which resulted in the loadmaster's improper restraint of the cargo, combined with the aircraft being loaded with more heavy vehicles than could safely be secured in it."[1] One of the key recommendations was to mandate training for all loadmasters.[9]

In media

The Canadian TV series Mayday (also known as Air Disasters and Air Emergency in the US and Air Crash Investigation in the UK and the rest of the world) covered Flight 102 in episode 10 of season 16, called "Afghan Nightmare", first broadcast in 2017.[18]

See also

Notes

  1. ^ The aircraft was a Boeing 747-400 model; Boeing assigns a unique code for each company that buys one of its aircraft, which is applied as a suffix to the model number at the time the aircraft is built, hence "747-428". This aircraft was converted to freighter configuration as part of Boeing's conversion program of passenger 747-400s, hence "747-428BCF" for Boeing Converted Freighter.

References

  1. ^ a b c d e f g h Hradecky, Simon (April 29, 2013). "Crash: National Air Cargo B744 at Bagram on Apr 29th 2013, lost height shortly after takeoff". The Aviation Herald. Retrieved April 30, 2013.
  2. ^ "Seven killed in US cargo plane crash at Afghan base". BBC News. April 29, 2013. Retrieved May 1, 2013.
  3. ^ a b "NTSB Finds Damage From Inadequately Secured Cargo Caused Boeing 747 Crash in Bagram, Afghanistan" (Press release). National Transportation Safety Board. July 14, 2015. Archived from the original on July 17, 2015. Retrieved October 18, 2015.
  4. ^ "Information Related to Flight NCR102". National Air Cargo. Archived from the original on 1 May 2013. Retrieved 6 May 2013.
  5. ^ a b Ahlers, Mike (May 6, 2013). "Video of Bagram plane crash legitimate, U.S. official says". CNN. Retrieved May 6, 2013.
  6. ^ a b c Yan, Holly; Alsup, Dave (May 1, 2013). "Cargo plane crashes in Afghanistan, killing 7 Americans". CNN. Retrieved May 1, 2013.
  7. ^ a b c Ranter, Harro. "N949CA accident synopsis". aviation-safety.net. Aviation Safety Network. Retrieved May 9, 2013.
  8. ^ "FAA Registry (N949CA)". Federal Aviation Administration.
  9. ^ a b c d e f "Steep Climb and Uncontrolled Descent During Takeoff, National Air Cargo, Inc., dba National Airlines, Boeing 747-400 BCF, N949CA, Bagram, Afghanistan, April 29, 2013" (PDF). National Transportation Safety Board. July 14, 2015. NTSB/AAR-15/01. Archived (PDF) from the original on August 26, 2023. Retrieved July 13, 2019.
  10. ^ "Operations - Attachment 2 - Crew Information" (PDF). National Transportation Safety Board. February 15, 2015. DCA13MA081. Retrieved July 13, 2019.
  11. ^ Hoedl, Chelsea (June 15, 2014). "Yankee Air Museum ceremony honors 7 crew members killed in Afghanistan 747 plane crash". mlive.com. Retrieved July 13, 2019.
  12. ^ 'We're all devastated': Americans killed in 747 crash mourned[dead link]
  13. ^ "7 Americans killed in Afghan cargo plane crash". CTV News. Associated Press. May 1, 2013. Archived from the original on May 1, 2013. Retrieved October 8, 2020.
  14. ^ a b "Remembering the crew of National Airlines Flight 102". WordPress. Retrieved October 8, 2020.
  15. ^ "Plane crash stalls Afghan withdrawal". 3 News NZ. May 2, 2013. Retrieved May 2, 2013.
  16. ^ "N936CA National Airlines Boeing 747-446(BCF)". www.planespotters.net. October 15, 2021. Retrieved October 31, 2021.
  17. ^ "NTSB to assist Afghan authorities with investigation into Bagram cargo plane crash" (Press release). National Transportation Safety Board. April 30, 2013. Archived from the original on May 3, 2013. Retrieved May 5, 2013.
  18. ^ "Air Crash Investigation – Episodes season 15". NG Europe. Archived from the original on February 11, 2017. Retrieved February 15, 2017.

External links

  • National Transportation Safety Board
    • NTSB preliminary report
    • NTSB Final Aircraft Accident Report
    • NTSB investigation docket
  • "Information Related to Flight NCR102." National Air Cargo (Archive)
  • "STATEMENT FROM NATIONAL AIR CARGO." EVA International Media. 2 May 2013. (Archive)
Retrieved from "https://en.wikipedia.org/w/index.php?title=National_Airlines_Flight_102&oldid=1217181199"